White Smelly Goop

LewTwo

1 MW
Joined
Apr 8, 2014
Messages
2,119
Location
Houston, Texas
Where does one get that white smelly goop that our Chinese brethren are so fond of smearing all over electronics ?
Can I just use silicone rtv caulk instead ?

While I am asking stupid questions:
What about 16 pin JST connector (aka balance leads for 16 cell batteries)?
 
I thought it was more of a heat transfer type goop they put on the backside of the controller fets to help heat transfer from the fet backboard to the outter casing. Thats the only time I ever see the white smelly goop.
Is that the stuff you are talking about?
 
I have seem them use it for glueing down all sorts of things from coils to capacitors.
I think sometimes they just use it to cover things up like the part number of an IC.
 
You need that goop on the fets, where they bolt to the heat sink. RTV can be used to stick down or support something that might wiggle enough to break, like daughter boards.
 
They use that paste because it is cheap and never dries. They don’t care about the smell, when the paste that smells better is 4 times the cost. Silicon is not a good heat transfer material, can’t be applied as easily, and does smell even worse when it is applied.
 
Oh yeah they use silicone to help save components from vibration. Mechanically fixes heavy or flimsy components to the board to prevent them from moving because of vibration, and breaking off the legs or cracking solder joints. Use neutral or electronics grade silicone.

You can use anything with a half decent temp rating. But I found this
DOW CORNING 744 WHITE seems to be the most commonly sold silastic/RTV for electronics repairs.


Doctorbass talked about it in a few of his posts. LFP might have talked about it to.
My initial searches didnt find which product to use but the key point would be the heat rating.
https://endless-sphere.com/forums/viewtopic.php?f=14&t=52560&p=783928&hilit=silicone#p783928



Silastic
 
There's a few kinds of "white smelly goop", but two of them are really common inside ebike stuff.

If it is rubbery and not smearable, a "glue" that holds parts down, that's just RTV silicone. Use the kind that does *not* have acetic acid (vinegary smell) if you're putting it on stuff where it may contact metals, wires, electronics' contacts/pads/etc., or it may over time cause corrosion. I use GE Silicone II from Lowes in the big caulking gun tube. I usually use the clear version instead of white, just so I can see what's under it later if I have to do a repair. ***

If it is kind of sticky and smearable (or sticky and powdery), then that's thermal paste, or heatsink compound, etc. Titanium dioxide in a carrier (which usually dries out and if there's too much paste between the objects being connected by it, will now have an air gap and it is worse than if they had never put any at all :( "too much paste" being any more than is needed to *just fill* the tiny scratches and surface imperfections on the faces being connected--if you can see the paste smeared around on it, there's too much). There are a bajillion different kinds in all sorts of price ranges, and generally the cheapest gunk works *almost* as well as the most expensive, as long as they are both applied correctly. ;)



A less common kind is inside some gearboxes, throttles, geared hubmotors, etc., and feels slimy and sometimes sticky. THat's white lithium grease, usually.



*** I also use GE Silicone I for sealing up other things than metals, especialy things I have to be exposed to, becuase it has acetic acid instead of the long chemical-name solvents, and it cures without a remaining toxic smell to me...but it's not suitable for things with exposed corrodable metals, in my experience. :(
 
I found four silicone adhesive/caulk products on Amazon specifically listed for electrical applications.

White Electronic Grade Silicone - 10.2 oz Cartridge $15.04 + Shipping $5.15
https://www.amazon.com/dp/B0063U2RHK

Gc Electronics Adhesive, Silicone, Tube, 3Fl.oz.(Us) - 19-155 $4.60 + Shipping $4.61
https://www.amazon.com/dp/B004SPJN6K

ASI 388 Clear Electronic Grade Silicone - 2.8 oz Squeeze Tube $13.24
https://www.amazon.com/dp/B0063U2RT8

Electronics Grade Silicone Adhesive Sealant 20g (0.035 oz) Squeeze Tube (White) $6.95
https://www.amazon.com/dp/B07PG9X9L8

I am reasonably certain some of the high temperature food grade silicone adhesive/caulk products would work for some purposes.

Food Grade NSF RTV Silicone Sealant Adhesive White 2.8 Ounce $6.50
https://www.amazon.com/dp/B01F9HCISU
Warning: acetoxy cure
Releases acetic acid during curing (vinegar smell)

OH ... there is always 'Hot glue' (EVA Resin) as an alternative as well.
 
Pretty sure you’re talking about heatsink compound. Really just used to transfer heat so that so that high temp components don’t burn up as quickly.
 
magilacutys said:
Pretty sure you’re talking about heatsink compound. Really just used to transfer heat so that so that high temp components don’t burn up as quickly.
NEGATIVE ... I am not talking about heat sink compound.
https://www.amazon.com/dp/B08VN345D4
Heat Sink Compound3.jpg

I am talking about the stuff the Chinese manufacturers dribble over electronic assemblies to hold things in place such as coils and capacitors. Occasionally used to hide component part numbers as well.
 
Back
Top